-
1
Make Nashville Sweet: combine all the ingredients in a saucepan; whisk to mix.
-
2
Let the sauce gradually come to a simmer over medium heat; simmer until thick and flavorful, 8-10 minutes; if not serving sauce immediately, let cool to room temperature; transfer to clean glass jars and refrigerate until ready to serve; bring to room temperature before using.
-
3
Make the rub: add rub ingredients to a bowl; stir to mix (or use your fingers); stor rub in an airtight jar away from heat or light (keeps for 6 months); makes 2 cups; total amount used in this recipe is 2 tablespoons.
-
4
Make the pork: butterfly the pork loin-using a very sharp knife, cut the roast almost in half lengthwise through one side (stop about 1-inch from the opposite side).
-
5
Open the roast up as you would a book.
-
6
Sprinkle the inside of the roast with 1 tablespoon of the whiskey; let is marinate for 5 minutes.
-
7
Sprinkle a third of the rub (remember total amount of rub used it 2 tablespoons, so 1/3 of that amount) over the inside of the roast.
-
8
Spread the mustard on top with a spatula; sprinkle the brown sugar on top of mustard.
-
9
Sprinkle the remaining 2 tablespoons whiskey on top of the brown sugar.
-
10
Fold the roast back together (like closing a book); sprinkle the remaining rub over the outside.
-
11
Cut four 12-inch pieces of butcher's string; position the pieces of string on your work surface so they are parallel and about 2 inches apart.
-
12
Place a slice of bacon across the strings so that it is perpendicular to and in the center of them.
-
13
Set the roast on top of the bacon, positioning its long side parallel to the bacon.
-
14
Place a slice of bacon on top of the roast; press the remaining 2 slices against the long sides of the roast.
-
15
Tie each piece of string together around the roast so that they hold the slices of bacon against it; set roast aside.
-
16
To make the glaze: combine the glaze ingredients together in a saucepan; boil until syrupy, 4-6 minutes; set the glaze aside.
-
17
Set up grill for indirect grilling and preheat to medium (if using a gas grill, place all of the wood chips in the smoker box or in a smoker pouch and run the grill on high until you see smoke, then decrease the heat to medium; if using a charcoal grill, place a large drip pan in the center, preheat the grill to medium, then toss all of the wood chips on the coals).
-
18
When ready to cook, place the pork roast on the grate, over the drip pan and away from the heat; cover the grill.
-
19
Cook roast until cooked through, 1 to 1 1/2 hours; test for doneness by inserting an instant read thermometer into the side of the roast; internal temperature should be about 160u00b0.
-
20
Start basting the roast with some of the glaze after 30 minutes and continue basting every 15 minutes.
-
21
Transfer cooked roast to a cutting board; let rest for 5 minutes; remove and discard strings; slice roast crosswise and drizzle any remaining glaze over it.
-
22
Serve with Nashville Sweet.
